How To Repair Water Pump Outboard Not Working Tutorial

Home > Water Pump > Water Pump Outboard Not Working

Water Pump Outboard Not Working

Contents

Dangar Marine 124,827 views 7:20 How to Replace an Outboard Water Pump - Duration: 19:52. Midrange Midrange Four Stroke F90 | F75 | F70 | F60 | F50 | F40 | F30 | F25 Power everything from deep-V hulls to pontoons to center consoles and more. What;s the serial #? Rubber has a tendancy to break down when not in use. have a peek at this web-site

and check the impeller it should pee the only motor I seen that dont pee is those little air cool ones. You can only upload files of type PNG, JPG, or JPEG. The tips of the impeller vanes can wear out from simple use, but if the motor is often run in silty or sandy conditions, this abrasive material can accelerate impeller wear. boats.com is part of the Dominion Marine Media Network.

Outboard Motor Water Pump Test

We go through checking for blocks in the tube and outlet nozzle, removing the thermostat to see if water is reaching the block and then removing the gearbox to check the Water pump was replaced just last year and once lower end unit was fully submerged at ramp it started pissing right way. Dangar Marine 26,633 views 29:45 Outboard Water Cooling System Overview - Duration: 3:53.

  1. Make sure you go far enough up.WarrenMN the_grumpParticipant Le CenterPosts: 618 August 8, 2006 at 3:13 pm #467394 There is a very good chance the impeller has dried up and cracked
  2. Show more Language: English Content location: United States Restricted Mode: Off History Help Loading...
  3. Take care REW Munshaw08-16-2011, 01:58 PMCould it be that the water guide tube is not seated properly from the water pump to the water tube in the midsection of the motor?
  4. Please upload a file larger than 100x100 pixels We are experiencing some problems, please try again.
  5. Ther is only about maybe a cup coming out every minute.
  6. Good luck.
  7. Thermostat?

Betcha she starts pissing it always takes a little time. PM me if you are interested. I'd be asking if you have enough water pressure? Mercury Outboard Water Pump Indicator Hole Water is inducted through the lower unit by a water pump impeller, and then forced upward to circulate throughout the powerhead, and eventually exits through the exhaust system.

Marine in Fond du Lac, Wis. “Even with our short season, I find a lot of impellers that are too worn at the tips to pump well, or are really stiff. Mercury Outboard Water Pump Troubleshooting Pumps like a charm now! Is there some sort of filter or shut off valve at the top of the pipe from the water pump?

There isn't any sort of filter or shutoff, but a chunk of crud or a mud dobber's nest could block off the water line.

If compression is good, pull the LU and get that water pump serviced. Mercury Outboard Water Flow Diagram Trending What is the name of the thing that rows the boat? 8 answers Do ocean liners still exist? 7 answers What are some tips for cleaning a boat? 5 answers Outboard water pumps are not made to lift water. Electronics on your Skeeter Help! 20 guage slug shoots too high Deer Camp Stories Rock River Lake Koshkonong November Fishing Reports 14' Lund Boat Vikings…… Deer and cats.

Mercury Outboard Water Pump Troubleshooting

For the best results, please start a new topic. So now I know I have plenty of pressure shooting water up the inlet pipe, but nothing getting to the thermostat. Outboard Motor Water Pump Test I am thinking that this might give me a better view of where the blockage might be as I can't get to it from the water pump or from the top. How To Tell If Your Outboard Water Pump Is Bad Any one with any knowledge want to come to East Bethel and drink free beer, supervise a novice, and offer constructive advice????

Password: Confirm Password: Please enter a password for your user account. Check This Out Reply † Reply With Quote + Reply to Thread Page 1 of 2 12 Last Jump to page: vBulletin Message † Cancel Changes Errors The following errors occurred with your submission Outboard water pumps are not made to lift water. put the motor in clean trash barrel instead of the muffs. How To Tell If Water Pump Is Bad On Outboard

on Mapquest) To far for me to go because I have some other things to do, but, if you find out for sure that it is possibly/most likley, the water pump, Now ... Please note that you should see a red banner pop up near the bottom of each inactive topic asking you not to reply to old topics. Source We trailered the boat over to the river and put the motor in until it covered up to the cavitiation plate.

Are there any special tips on dropping the drive shaft housing? Johnson Outboard Water Pump Test Motor started right and pissed fine after that. Make sure you diagnose and correct the problem…not just a symptom.

Again, the motor was not pissing any water.

Dan Riveness fishman1Participant Dubuque, IowaPosts: 1,030 August 8, 2006 at 5:23 pm #467428 Like one of the other replys stated the impeler is more than likely shot from sitting so long Hope this helps jon_jordanParticipant St. By starting your own topic, you will receive the maximum number of views by forum helpers that may not even notice your question when itís posted at the end of someone Outboard Water Pump Clogged Login or Sign Up Log in with Boat Parts & Accessories Most Popular Categories Boat Covers Boat Propellers Bimini Tops Boat Motor Parts Boat Motors Boat Seats & Pontoon Furniture All

Lazer Auger Helix G2 and G2N Who's ready for some ice? Also, the inlet ports near the bottom of the lower unit could be plugged with gunk also. A:At idle, a trickle or dribbly flow from the discharge/tell-tale tube is fine. have a peek here You should be getting water out of your pee hole whether your thermostat is open or close.

Accessories Chrysler Outboard Force Outboard Johnson Evinrude Mercury Mariner Mercruiser Stern Drive OMC Cobra Stern Drive Yamaha Outboard Repair Manuals Help, I cant find it! eric edic 83,357 views 13:48 Yamaha Outboard Service Tutorial Sunrise Marine - Duration: 8:14. We make changing the impeller part of our off-season lay-up program, because if it fails you can have much more expensive problems.‚ÄĚThis Mercury outboard water pump was run dry briefly, and cj Reply † Reply With Quote 03-13-2011,†04:50 PM #11 ralpht44 Senior Member Join Date Nov 2005 Location Drexel Hill & North WIldwood Posts 582 My 225 Mercury does the same thing.