(Solved) Water Pump Caravan Not Working Tutorial

Home > Water Pump > Water Pump Caravan Not Working

Water Pump Caravan Not Working

Contents

When I turn on the hot water I only get hot water for about a minute than it goes cold. Curtis Tom R., I can't tell from here but they do make bladder tanks for RVs as an add on so the pump doesn't run every time you want a cup Curtis Tim, If your pump can't build up pressure it will continue to run. You may have a damaged diaphragm. have a peek at this web-site

Do you agree with this conclusion? The pump's not designed to have direct pressure city water hooked to it, city water pressure can be as high as 100 psi and will likely damage the pump too. It's should be somewhere that plumbing is going to be between the water tank and any of the fixtures that use water. Kj5962 My water pump runs but the water gets just short of the faucet. http://www.atlanticcaravans.co.uk/page/help-and-advice/why-wont-my-pump-work

My Caravan Water Pump Not Working

water pump problems any advice would be most welcome 6 years 1 month ago #310574 forestgump Offline Platinum Boarder Posts: 2167 Thank you received: 1 with damian sounds like a short Thanks Jim Curtis Jwshadowking, Hi Jim. Gentleman Jack shares his top tipsSee all in: Advice » Follow us onGet our newsletterNameEmailSubscribeMost recent motorhome reviewsMobilvetta K-Yacht Tekno Line MH-80£64,995OTRSwift Escape 694£44,875OTRElddis Autoquest 196£42,349OTRAuto-Trail Tracker RS£54,691OTRNomad Ranger£44,135OTRBailey Autograph 75-2£50,995OTR That being possible it's also possible you have a cracked suction line and the pump is either sucking air, or it may have just self destructed running dry for 4 hours.

  1. Many thanks in advance.If you think it may be the pressure switch,I have a pdf from Whale that tells you how to adjust it along with a few more helpful tips.If
  2. Battery has an impact Unfortunately, pressure switches react differently when the leisure battery’s state of charge is altered.
  3. Loading...
  4. The tiny pistons are moved up and down by a ‘wobble plate’ and, because grit can seriously damage the chambers, Whale supplies complete replacement headsas a pre-assembled unit.
  5. Tip:Even if you wouldn’t fit your own switch, carry some spares, especially if you’re touring abroad.
  6. This link http://tiny.cc/8l35jw will show you a variety of replacements.
  7. That's a strange one.

Is there a reset button or a breaker somewhere for the pump? When my batteries are above 13 true pump operates correctly, when the ten is running it operates correctly, BUT when the ten is not running and batteries are below 13 it If what I'm saying makes sense to you, tracing the wire won't be much of a problem for you. Truma Water Pump Not Working Can you help?

Curtis Kevin, Is there a shut off valve between the water tank and the inlet for the pump? Caravan Water Pump Working But No Water Tip:Check fuses serving the water system. Then screw the nob down a bit (about quarter of a turn in my case seems to work ok) until there is no clicking.

Replacing the city water connection is a simple do-it-yourself project.

Don’t replace — repair Unlike submersible models, diaphragm pumps can be repaired or completely overhauled. Surge Damper Caravan Swapping the switch Having removed the curved plastic activation plate, you then gently prise the microswitch upwards and away from its seating. And this year the pump wont pump water,tank is full filter is clean and i dont see any leaks. Question is 35 psi to high for pump cut in?

Caravan Water Pump Working But No Water

Also we used to turn it on just to pump enough water for conservative use, then turn off the pump, and then when water ran out turn on the pump again. the pump needs to build up pressure to shut off. My Caravan Water Pump Not Working Air-raising experience Preliminary priming occurs when this type of pump is immersed in water but air bubbles sometimes get trapped inside its casing. Whale Water Pump Not Working There is a check valve in the city water connection that apparently has failed.

I cut the hose and put in a different one that won't kink, but the pump still won't draw water out of the tank. Check This Out Simple! I have not found the answer yet but still looking. I forgot the shut off between the tank and pump myself this year and was puzzled for a few minutes wondering why I wasn't getting any water out the faucet. Caravan Water Pump Air Lock

The pump is on and it blows a little water and a lot of air. Our pump was doing exactly the same as yours ! But to the best of my knowledge, I do not have that kind of system. Source Curtis Isbinvegas, I'm doubtful an air gap is your problem.

water pump problems any advice would be most welcome 6 years 1 month ago #310575 Damian-Moderator Online Moderator Posts: 5536 Thank you received: 253 It makes no difference to the pump Rv Water Pump Troubleshooting Disconnect the positive wire at the pump. Dean Sigman My pump runs continually some times after running a faucet it the Rv.

The only determining factor in which pump to get is the fitting to the van inlet.

Most pumps have an adjusting screw to ensure that the tap will not operate during very slight pressure drops. Bacteria build upA common problem with fresh water systems is the accumulation of Water pump attached to van and in aquaroll with water. Switching polarity, not a good plan. No Water In Caravan Curtis 1985anderson, Some how air is being sucked in by the pump.

Boo! Back to top #18 Lefthand Down Lefthand Down Robert Jackson Award Winner Moderator 14,393 posts Gender:Male Location:East Midlands Interests:Steam Railways Photography Classical Music Fishing Posted 04 April 2012 - 09:12 pm Debris left from manufacturing may have partially plugged the removable screen on the faucet. have a peek here Of course if you did that it is likely many other things are toast as well.

Anyhow, your pump is protected by a fuse as it is 12volts DC. Tory I can't seem to find how to prime a pump at altitude in the link you have posted here. Order a new on amazon.com, a heck of a lot cheaper than from an RV dealer. I'm wondering if it is better to just leave it on?

Do you know what your system is? Created by Morgan Wylie The Caravan Club Sign in or Register My Profile Quick Links Search and book Search by map Club Sites Certificated locations Overseas sites Join online now Contact Any suggestions to our problem?? Johnykarla Curtis, I have a Shurflo pump that willinitially turn on and run fine but after it shuts off, due toit pressuring the lines, it won't turn back on.

WARNING!!! House wiring and outlets are rated at 20 amps.